Burundi biomass fired boiler

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



biomass boiler | eBay Find great deals on eBay for biomass boiler multi fuel boiler. Shop with confidence. oil fired central heating boiler | eBay Find great deals on eBay for oil fired central heating boiler oil boiler. Shop with confidence. New technologies reduce environmental impacts of coal New technologies reduce environmental impacts of coal-fired plants 21st February 2013 List of power stations in Indonesia Wikipedia, the free The following lists some of the larger power stations in Indonesia. Data are not included for a large number of small isolated plants (mostly diesel) in the Outer

Combustion of coffee husks ScienceDirect Combustion mechanisms of two types of coffee husks have been studied using single particle combustion techniques as well as combustion in a pilot-scale fluidise Product Selector Howden The fans that Howden engineer for boiler applications are based on a comprehensive understanding of the situations and applications for which they are destined. Lancom 4 Portable Gas Analyser | Land Instruments Boiler Servicing. Industrial boilers should be setup to maximise their combustion efficiency. Measurement of O 2 and CO along with efficiency calculations, make the Thermax Global Large Boilers The Boiler Heater Group, Thermaxs largest business division, provides equipment and solutions to generate steam, power and for process heating. LEED NC-2009 EAc2 On-Site Renewable Energy | LEEDuser Capturing useful energy from natural energy flows like sunshine, wind, moving water is a great concept. The technologies to capture this energy arent cheap,

Power Engineering Suppliers Directory Buyers Guide for Power Engineering Online provides up-to-the-minute energy news, stock quotes, five years of searchable editorial archives, power generation conference schedule and oil fired central heating boiler | eBay Find great deals on eBay for oil fired central heating boiler oil boiler. Shop with confidence. New technologies reduce environmental impacts of coal New technologies reduce environmental impacts of coal-fired plants 21st February 2013 Thermax Projects that Conserve Energy and Preserve the Large Boilers The Boiler Heater Group, Thermaxs largest business division, provides equipment and solutions to generate steam, power and for process heating. List of power stations in Indonesia Wikipedia, the free The following lists some of the larger power stations in Indonesia. Data are not included for a large number of small isolated plants (mostly diesel) in the Outer

Combustion of coffee husks ScienceDirect Combustion mechanisms of two types of coffee husks have been studied using single particle combustion techniques as well as combustion in a pilot-scale fluidise Product Selector Howden The fans that Howden engineer for boiler applications are based on a comprehensive understanding of the situations and applications for which they are destined. Thermax Global Large Boilers The Boiler Heater Group, Thermaxs largest business division, provides equipment and solutions to generate steam, power and for process heating. Peat as an Energy Resource | International Peatland Society Background. Since World War II there has been a big change in attitudes towards the use of peat as an energy source and the role of peatlands as a natural resource. LEED NC-2009 EAc2 On-Site Renewable Energy | LEEDuser Capturing useful energy from natural energy flows like sunshine, wind, moving water is a great concept. The technologies to capture this energy arent cheap,

Power Engineering Suppliers Directory Buyers Guide for Power Engineering Online provides up-to-the-minute energy news, stock quotes, five years of searchable editorial archives, power generation conference schedule and Lancom 4 Portable Gas Analyser | Land Instruments Boiler Servicing. Industrial boilers should be setup to maximise their combustion efficiency. Measurement of O 2 and CO along with efficiency calculations, make the Resources Global Alliance For Clean Cookstoves The Alliance produces a range of high-quality resources including: research reports, market assessments, customer segmentation and adoption studies, issue briefs, and FGA 900 Series Range of Stack Gas Emissions Analysers Fully integrated system in a single compact box no additional components required; Suitable for a wide range of applications up to 3 gases in a single analyzer Energy Engineering | Renewable Energy, Power Generation Future proofing Katherines electrical transmission and generation infrastructure. The Katherine Power Station provides vital power supply to the Katherine region