industry wood pellet fired boiler

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



biomass burner / wood chips sawdust burner/biomass Products Eco-Blaze. Eco-Blaze Corporations biomass burner systems offer an affordable, low Dual Burner Boiler System These burners are set up to burn Wood Fired Boiler | Coal Fired Boiler |Electric Wood Fired Boiler, Coal Fired Boiler, Electric Fired Boiler,Wood Fired Boiler, Coal Fired Boiler, Electric Fired Boiler,Wood Fired Boiler, Coal Fired Boiler, Electric Electric Boilers for Industries and properties. Electric boilers for industry, process and house property. Pellet burners and boilers, Wood fired boiler for domestic heating. Wood Pellet Stove for Sale , Small Pellet Boiler Pellet Boiler/Stove. Pellet boiler, cooking stove and biomass steam generator for sale. All these biomass fired boiler equipment are applicable for wood and biomass

Welcome | Central Boiler While a Central Boiler outdoor wood furnace itself is one of the most technologically advanced ways available to heat with wood, how it delivers heat is a pretty Fröling FHG High Efficiency Wood Boiler Wood Fröling FHG 20/30 Wood Boiler| 70,000 to 102,500 Btu/Hr High Efficiency Wood Boiler with Advanced Lambda Gasification Technology MY WOOD PELLET SOLUTION mywoodpelletsolution.com is sponsored by Pellergy, the experts in wood pellet central heat. Pellergy makes pellet burners and storage solutions to upgrade your boiler Econoburn 170-200 EPA Certifed Wood Boiler - This unit qualifies for New York State Tax Incentives. The Econoburn EBW 200-170 Gasification Wood Boiler meets the latest round of EPA Boiler Emissions and The New Pellet fuel Wikipedia, the free encyclopedia There are three general types of pellet heating appliances, free standing pellet stoves, pellet stove inserts and pellet boilers. Pellet stoves look like traditional

Henan Yuanda Boiler Co., Ltd.coal boiler,gas Henan Yuanda Boiler Co., Ltd. (former Xihua Boiler Factory), founded in 1956, is one of the first state permitted key boiler manufacturers. With production products Heatmor The leader in the stainless Unique modular design allows individual assemblies to easily be removed and replaced Stainless steel chimney lasts longer than mild steel Insulated firebox door E-Classic | Central Boiler Classic Edge. Central Boilers newest EPA-certified model line is the perfect combination of value and performance. E-Classic. The E-Classic 1450 and 3250 are EPA Outdoor Wood Boiler.ca The NC Outdoor Wood Furnace provides hot water to work in conjunction with your existing forced air, boiler or radiant floor, baseboard or radiator system as well Blog WoodMaster More Shivery and Shovelry are the words the Farmers Almanac chose to describe their prediction of this winter. I dont know about you, but after last years long

Utica Packaged Oil Fired BoilerWater. 140,000 PACKAGED OIL FIRED BOILER WATER. MODEL TriFire Series. DESCRIPTION The TriFire is an industry leading 3-pass oil-fired boiler. Installation is made easy with its Biomass Boilers Bioenergy Company. Bioenergy Technology Ltd. have installed hundreds of biomass boilers, heating and wood burning systems. As an accredited Microgeneration company we are able Boilers, Fireboxes All industrial manufacturers A boiler supplies energy to a thermal transfer liquid in order to heat, vaporize or superheat it. Applications. Hot water and superheated water boilers are used Pellet stove Wikipedia, the free encyclopedia A pellet stove is a stove that burns compressed wood or biomass pellets to create a source of heat for residential and sometimes industrial spaces. Wood pellet bio-fuel confined spaces HSE Domestic and commercial heating. Wood Pellet Boilers are commonly used in homes and businesses as an alternative to oil or gas fired boilers. Wood pellets for these

United States The Asian Wood Agriculture Pellet 1 The Asian Wood Pellet Markets Introduction Global wood pellet production was approximately 12 million metric tons in 2009, and is predicted to increase to 100